|
|
|
| Material Safety Data Sheet – EmulsdirtTM |
| Product Name |
: |
EMULSDIRT |
| Chemical Family |
: |
Alkaline detergent |
| Hazardous Material |
: |
Sodium dodecyl benzene sulfonate, ethylene glycol monobutyl ether, sodium metasilicate |
| Non-Hazardous Material |
: |
Protected under NJ trade |
|
| HEALTH HAZARD INFORMATION: |
Ingestion causes severe burns of the mucous membranes of the mouth, esophagus and stomach, pain in the throat and stomach with difficulty in swallowing, intense thirst, nausea and vomiting followed by diarrhea are common. In severe cases, collapse and unconsciousness follow this. Eye contact causes severe irritation and painful burns of the eyes and eyelids. Skin contact with concentrate causes reddening.
Repeated skin contact with diluted product may lead to the development of dermatitis. Inhalation of excessive concentration of vapours or mists produces severe irritation of respiratory tract with coughing, burning of the throat and a choking sensation.
Chronic:
Chronic ingestion may produce fatal effects from esophageal or gastric necrosis. Dental discoloration and erosion of exposed teeth occur on prolonged exposure to low concentrations of hydrochloric acid vapours. Eye exposures may result in prolonged or permanent visual impairment or total loss of sight. Chronic skin exposures can yield ulceration and subsequent scarring. The irritant effect of vapours on the respiratory tract may produce laryngitis, glottal edema, bronchitis, pulmonary edema and death. Inhalation of vapours may aggravate existing medical conditions of the respiratory tract such as asthma. Target organs: None known although there are no known target organs; skin and eye contact are possible methods of exposure.
First Aid
Inhalation:
Remove from the area to fresh air. If not breathing, clear airway and start mouth to mouth artificial respiration. Get immediate attention.
Eye:
Rinse thoroughly with water and flush for atleast 15 minutes. Get immediate medical attention.
Skin:
Wash with large amounts of water. Contact a physician if irritation persists. Clean clothes and shoes before reuse.
Swallowed:
Do not induce vomiting. Give large quantities of water.
Advice to physician: Diagnose for erythropenia, reticulocytosis, granulocytosis, leucocytosis caused due to abnormal blood picture. |
| PHYSICAL DESCRIPTION/PROPERTIES: |
| Appearance |
: |
Yellsowish green transparent liquid |
| Boiling Point |
: |
210 degrees Fahrenheit |
| Vapour pressure |
: |
17mm Hg at 25 degrees Celsius |
| Specific Gravity |
: |
1.03 at 25 degree Celsius |
| Viscosity |
: |
Non-Viscous |
| Flammability |
: |
Non-Flammable (flash point: N/A) |
| Solubility in water |
: |
Complete |
| pH |
: |
> or =12.0 |
| Vapor density |
: |
0.6 |
| Evaporation Rate |
: |
<1 |
|
| REACTIVITY DATA: |
| Incompatibility: Strong acids, oxidizing agents, alkalis, don’t allow long term contact with zinc magnesium or Aluminium. Hazardous Polymerization: N/A |
| SPILL OR LEAK PROCEDURES: |
Steps to be taken if released / spilled:
Contain the material by diking with sand. Wash area with water.
Neutralizing agent: Dilute hydrochloric acid.
Waste disposal method:
Dispose in accordance with state, federal and local regularations. |
| SPECIAL PROTECTION INFORMATION: |
Provide adequate ventilation, use NIOSH approved respiratory mask, neoprene or nitrile gloves, eye goggles, protective clothing while handling the product |
| STORAGE AND HANDLING INFORMATION: |
Storage and transport:
Maximum Storage temp: 120 degrees Fahrenheit
Minimum Storage temp: 32 degrees Fahrenheit
Store at moderate temperatures. Always store the product in the original container.
Precautions:
Rinse the product contacting surfaces with potable water after use.
Read entire label before use.
Keep out of reach of children.
|
|
| |
|
|
